河北駿豪機械設備有限責任公司

聯系人：張經理13933000298

堆高車電機的保養（1）為保證電池壽命，電池投入使用前應充足電，充電不足的電池不可使用。（2）電池盡量避免過充和過放。電池過充和過放會嚴重影響電池性能和壽命。（3）電池液孔塞和氣蓋應保持清潔，充電時取下或打開電完畢應裝上或閉合。電池表面、連接線及螺釘應保持清潔、干燥。如有硫酸，用棉紗蘸上堿液擦去，應注意不要讓堿液進入電池內。（4）充電完成后，應檢查電池液位，及時補加蒸餾水以保持液面高度。正常情況下嚴禁補加稀硫酸。（5）電池使用后，應及時充電，放置時間一般不超過24小時。（6）充電時應保持良好的通風，嚴禁煙火。（7）出現下列情況，電池需作均衡充電。
Maintenance of stack motor (1) in order to ensure battery life, the battery should be fully charged before use, rechargeable batteries can not be used. (2) the battery avoids overcharge and over discharge as much as possible. Overcharge and over discharge of batteries can seriously affect battery performance and life. (3) the battery plug and the gas cap shall be kept clean. When the charge is taken off or turned on, the power shall be installed or closed. The battery surface, wires and screws shall be kept clean and dry. If there is sulfuric acid, with cotton dipped in lye wipe, should be careful not to let lye into the battery. (4) after charging, check the battery level and add distilled water in time to keep the liquid level high. Under normal circumstances, do not add dilute sulfuric acid. (5) after the battery is used, it should be charged in time, and the storage time is not more than 24 hours. (6) good ventilation should be maintained when charging. No fireworks. (7) the battery should be charged evenly when the following conditions occur.

三月，醉一場青春的流年。我們珍惜三月，就像我們珍惜來之不易的幸福青春。三月的雨，三月的風，三月的春光，三月的花香，讓我們沉醉不知?dú)w路，興盡晚回舟。在這樣一場盛大而清新的流年，我們懂得，青春是一種一去不復返的風景，應當好好保護；青春是一種美麗而活躍的熱情，我們必須耐心保持；青春是一種來之不易的懂得，我們必須細心呵護。

堆高車驅動輪速度明顯降低或驅動電機嚴重過載：原因：電池電壓太低或樁頭接觸電阻太大；電機換向器片間積碳引起片間短路；電機制動器調整不當而使電機帶制動運行；驅動頭齒輪箱及軸承缺少潤滑或底座卡阻；電機電樞短路。解決方法：檢查堆高車負載時電池端電壓或清洗樁頭；清理?yè)Q向器；調整制動器間隙；檢查清洗并重新加注潤滑油，清除卡阻現象；更換新電機。
Forklift truck driving wheel speed decrease or drive motor overload causes: the battery voltage is too low or the pile head contact resistance is too large; the motor commutation carbon caused by short-circuit between plates; improper adjustment of the motor brake motor with brake operation; driving head gear box and the bearing base resistance or lack of lubrication card; motor armature short-circuit. Solution: check the battery load at the end of the stack truck or clean the pile head; clean the commutator; adjust the brake clearance; check, clean and refill the oil, remove the obstruction; replace the new motor.

三月，醉一場青春的流年。風過無痕，花開向暖。無論是哪一年的三月，都是青春是里最美麗的花朵，都是青春里最難舍的風景，都是青春里最嫵媚的清香。無論在哪一年的三月，無論我們有沒有老去，心中的青春千萬不能割舍，心中的青春永遠跳動著快樂，心中的青春永遠伴隨我們一生一世。

堆高車起重?zé)o力或不能起重原因：齒輪泵與泵提磨損過度；換向閥內的溢流閥高壓不當；油壓管路漏油；液壓油油溫過度；門架滑架存在卡阻現象；油泵電機轉速過低。解決方法：更換磨損或齒輪泵；重新調整；檢查并修復；更換不合格的液壓油并檢查油溫度升高的原因；檢查并調整；檢查電機并排除故障。
Stacker crane lifting to reason: the gear pump and the pump provided excessive wear; high pressure solenoid valve relief valve in hydraulic pipeline improper; leakage; excessive oil temperature; the door frame carriage are blocked; the pump motor speed is too low. Solution: replace wear or gear pumps; readjust; check and repair; replace faulty hydraulic oil and check the cause of elevated oil temperature; check and adjust; check motor and troubleshoot.